(a) Process wastewater. Except as specified in paragraph (c) of this section, the owner or operator of each affected source shall comply with the HON wastewater requirements in Sec. Sec. 63.132 through 63.147 for each process wastewater stream originating at an affected source, with the HON leak inspection requirements in Sec. 63.148, and with the HON requirements in Sec. 63.149 for equipment that is subject to Sec. 63.149, with the differences noted in paragraphs (a)(1) through (20) of this section. Further, the owner or operator of each affected source shall comply with the requirements of Sec. 63.105(a) for maintenance wastewater, as specified in paragraph (b) of this section.
(1) Owners and operators of affected sources are not required to comply with the HON new source wastewater requirements in Sec. 63.132(b)(1) and Sec. 63.132(d) for the purposes of this subpart. Owners or operators of all new affected sources, as defined in this subpart, shall comply with the HON requirements for existing sources in Sec. Sec. 63.132 through 63.149, with the exceptions noted in paragraphs (a)(2) through (20) of this section.
(2) The provisions of paragraphs (a)(2)(i), (ii), and (a)(10)(iii) of this section clarify the organic HAP that an owner or operator shall consider when complying with the requirements of Sec. Sec. 63.132 through 63.149.
(i) Owners and operators are exempt from all requirements in Sec. Sec. 63.132 through 63.149 that pertain solely and exclusively to organic HAP listed on Table 8 of 40 CFR part 63, subpart G.
(ii) When the HON requirements in Sec. Sec. 63.132 through 63.149 refer to Table 9 compounds, the owner or operator is only required to consider compounds that meet the definition of organic HAP in Sec. 63.1423 and that are listed in Table 9 of 40 CFR part 63, subpart G, for the purposes of this subpart.
(iii) When Sec. Sec. 63.132 through 63.149 refer to compounds in Table 36 of 40 CFR part 63, subpart G, or compounds in List 1 or List 2 of Table 36 of 40 CFR part 63, subpart G, the owner or operator is only required to consider compounds that meet the definition of organic HAP in Sec. 63.1423 and that are listed on Table 36 of 40 CFR part 63, subpart G, for the purposes of this subpart.
(3) When the determination of equivalence criteria in Sec. 63.102(b) is referred to in Sec. Sec. 63.132, 63.133, and 63.137, the General Provisions' alternative nonopacity emission standard provisions in Sec. 63.6(g) shall apply for the purposes of this subpart.
(4) When the HON storage vessel requirements contained in Sec. Sec. 63.119 through 63.123 are referred to in Sec. Sec. 63.132 through 63.148, the HON storage vessel requirements in Sec. Sec. 63.119 through 63.123 are applicable, with the exception of the differences referred to in the storage vessel requirements in Sec. 63.1432, for the purposes of this subpart.
(5) When the HON process wastewater reporting requirements in Sec. 63.146(a) require the submission of a request for approval to monitor alternative parameters according to the procedures specified in Sec. 63.151(f) or (g), the owner or operator requesting to monitor alternative parameters shall follow the procedures specified in Sec. 63.1439(f) for the purposes of this subpart.
(6) When the HON process wastewater recordkeeping requirements in Sec. 63.147(d) require the owner or operator to keep records of the daily average value of each continuously monitored parameter for each operating day as specified in the HON recordkeeping provisions in Sec. 63.152(f), the owner or operator shall instead keep records of the daily average value of each continuously monitored parameter as specified in Sec. 63.1439(d), for the purposes of this subpart.
(7) When Sec. Sec. 63.132 through 63.149 refer to an ``existing source,'' the term existing affected source, as defined in Sec. 63.1420(a)(2), shall apply for the purposes of this subpart.
(8) When the HON requirements in Sec. Sec. 63.132 through 63.149 refer to a ``new source,'' the term new affected source, as defined in Sec. 63.1420(a)(3), shall apply for the purposes of this subpart.
(9) When the HON process wastewater provisions in Sec. 63.132 (a) and (b) refer to the ``applicable dates specified in Sec. 63.100 of subpart F of this part,'' the applicable compliance dates specified in Sec. 63.1422 shall apply, for the purposes of this subpart.
(10) Whenever the HON process wastewater provisions in Sec. Sec. 63.132 through 63.147 refer to a Group 1 wastewater stream or a Group 2 wastewater stream, the definitions of these terms contained in Sec. 63.1423 shall apply, for the purposes of this subpart.
(11) When the HON control requirements for certain liquid streams in open systems, in Sec. 63.149(d), refer to ``Sec. 63.100(f) of subpart F,'' the phrase ``Sec. 63.1420(c),'' shall apply for the purposes of this subpart. In addition, where Sec. 63.149(d) states ``and the item of equipment is not otherwise exempt from controls by the provisions of subparts A, F, G, or H of this part,'' the phrase ``and the item of equipment is not otherwise exempt from controls by the provisions of subparts A, F, G, H, or PPP of this part,'' shall apply for the purposes of this subpart.
(12) When the HON control requirements for certain liquid streams in open systems, in Sec. 63.149(e) (1) and (2), refer to ``a chemical manufacturing process unit subject to the new source requirements of 40 CFR 63.100(l) (1) or (2),'' the phrase ``a new affected source as described in Sec. 63.1420(a)(4),'' shall apply for the purposes of this subpart.
(13) When the HON Notification of Compliance Status requirements contained in Sec. 63.152(b) are referred to in the HON process wastewater provisions in Sec. 63.138 or Sec. 63.146, the Notification of Compliance Status requirements contained in Sec. 63.1439(e)(5) shall apply for the purposes of this subpart. In addition, when the HON process wastewater provisions in Sec. 63.138 or Sec. 63.146 require that information be reported according to Sec. 63.152(b) in the HON Notification of Compliance Status, owners or operators of affected sources shall report the specified information in the Notification of Compliance Status required by Sec. 63.1439(e)(5), for the purposes of this subpart.
(14) When the HON Periodic Report requirements contained in Sec. 63.152(c) are referred to in the HON process wastewater provisions in Sec. 63.146, the Periodic Report requirements contained in Sec. 63.1439(e)(6) shall apply for the purposes of this subpart. In addition, when Sec. 63.146 requires that information be reported in the HON Periodic Reports required in Sec. 63.152(c), owners or operators of affected sources shall report the specified information in the Periodic Reports required in Sec. 63.1439(e)(6), for the purposes of this subpart.
(15) When the term ``range'' is used in the HON requirements in Sec. Sec. 63.132 through 63.149, the term ``level'' shall be used instead, for the purposes of this subpart. This level shall be determined using the procedures specified in parameter monitoring procedures in Sec. 63.1438.
(16) When the HON process wastewater monitoring and inspection provisions in Sec. 63.143(f) specify that the owner or operator shall establish the range that indicates proper operation of the treatment process or control technique, the owner or operator shall instead comply with the requirements Sec. 63.1438 (c) or (d) for establishing parameter level maximums/minimums, for the purposes of this subpart.
(17) When the HON process wastewater provisions in Sec. 63.146(b) (7) and (8) require that ``the information on parameter ranges specified in Sec. 63.152(b)(2)'' be reported in the HON Notification of Compliance Status, owners and operators of affected sources are instead required to report the information on parameter levels in the Notification of Compliance Status as specified in Sec. 63.1439(e)(5)(ii), for the purposes of this subpart.
(18) For the purposes of this subpart, the owner or operator is not required to comply with the HON process wastewater emission reduction provisions in Sec. 63.138(g).
(19) When the provisions of HON process wastewater provisions in Sec. 63.139(c)(1)(ii), Sec. 63.145(d)(4), or Sec. 63.145(i)(2) specify that Method 18, 40 CFR part 60, appendix A shall be used, Method 18 or Method 25A, 40 CFR part 60, appendix A may be used for the purposes of this subpart. The use of Method 25A, 40 CFR part 60, appendix A shall comply with paragraphs (a)(19) (i) and (ii) of this section.
(i) The organic HAP used as the calibration gas for Method 25A, 40 CFR part 60, appendix A shall be the single organic HAP representing the largest percent by volume of the emissions.
(ii) The use of Method 25A, 40 CFR part 60, appendix A is acceptable if the response from the high-level calibration gas is at least 20 times the standard deviation of the response from the zero calibration gas when the instrument is zeroed on the most sensitive scale.
(20) The owner or operator of a facility which receives a Group 1 wastewater stream, or a residual removed from a Group 1 wastewater stream, for treatment pursuant to the HON provisions in Sec. 63.132(g) is subject to the requirements of Sec. 63.132(g), with the differences identified in this section, and is not subject to the NESHAP from off-site waste and recovery operations in 40 CFR part 63, subpart DD, with respect to the received material.
(b) Maintenance wastewater. The owner or operator of each affected source shall comply with the HON maintenance wastewater requirements in Sec. 63.105, with the exceptions noted in paragraphs (b) (1), (2), and (3) of this section.
(1) When the HON maintenance wastewater provisions in Sec. 63.105(a) refer to ``organic HAPs listed in Table 9 of subpart G of this part,'' the owner or operator is only required to consider compounds that meet the definition of organic HAP in Sec. 63.1423 and that are listed in Table 9 of 40 CFR part 63, subpart G, for the purposes of this subpart.
(2) When the term ``maintenance wastewater'' is used in the HON maintenance wastewater provisions in Sec. 63.105, the definition of ``maintenance wastewater'' in Sec. 63.1423 shall apply, for the purposes of this subpart.
(3) When the term ``wastewater'' is used in the HON maintenance wastewater provisions in Sec. 63.105, the definition of ``wastewater'' in Sec. 63.1423 shall apply, for the purposes of this subpart.
(c) Compliance date. The compliance date for the affected source subject to the provisions of this section is specified in Sec. 63.1422.[64 FR 29439, June 1, 1999, as amended at 65 FR 26501, May 8, 2000]